[mkiv] Drive Pulley woes

[Aaron Rountree]

Mine started squealing when initially starting the car. I couldn't pinpoint
where it was coming from and it didn't last long enough to really trace the
noise. Then one day the outside ring just fell off on the ground.

Aaron
'93 T78

-----Original Message-----
From: mkiv-bounces at mkiv.com [mailto:mkiv-bounces at mkiv.com] On Behalf Of
Marlon S
Sent: Friday, July 29, 2005 10:16 AM
To: The MKIV.com National Mailing List
Subject: Re: [mkiv] Drive Pulley woes

Were there any warnings signs before the pulley
broke(ie, unusual noises from the engine bay) or it
came without any warning?


--- Casey Ausmus <knightsport2003 at yahoo.com> wrote:

>    Mine broke too. You'll find it's one of the few
> but very common failures on Supra's. I replaced mine
> with an Unorthodox Racing(Billet) pulley but I
> wouldn't reccomend it even though it was the
> cheapest and lightest alternative. I drive my car
> everyday and the idle is a bit rough now. The SFI
> approved dampened pulley from Boost Logic would be
> they way to go IMHO. You get the improved response
> without the idle being adversely affected.
>  
>    Also, if you mess up with the puller getting the
> pulley off, I have a $50 tap bought from a specialty
> German tool company that will rethread the crank. =P
>  
> -Casey
> '96 TT
> 
> "W.F. (Bill) Lawry" <cmci at fcc.net> wrote:
> My drive pulley broke too (somewhere around the 200K
> mark). The cause was
> my A/C compressor freezing up. I guess that any
> accessory or a combination
> could put enough load on the belt to break the drive
> pulley.
> 
> ----- Original Message ----- 
> From: "Bob" 
> To: 
> Sent: Thursday, July 28, 2005 10:30 PM
> Subject: [mkiv] Drive Pulley woes
> 
> 
> >
> >
> > Hi, folks
> >
> > I thought my serpentine belt broke today on my '94
> TT but it turns out
> that
> > the drive pulley fell apart. Apparently it's a two
> piece thing with some
> > rubber inbetween. Thankfully, it happened less
> than a block from my home.
> >
> > My question is this...is there any way to repair
> this or am I stuck
> pulling
> > and replacing the complete part? If so, do you
> have any guesses what kind
> of
> > a price these things go for? My problem is that my
> other car ('91 MR2)
> just
> > lost it's fuel pump so now I'm out of wheels for
> the first time in my life
> > (both first failures for either car and in the
> same week!)
> >
> > Thanks so much,
> >
> > Bob
> >
> > _______________________________________________
> > Mkiv mailing list
> > Mkiv at mkiv.com
> > http://www.mkiv.com/mailman/listinfo/mkiv
> >
> >
> 
> 
> _______________________________________________
> Mkiv mailing list
> Mkiv at mkiv.com
> http://www.mkiv.com/mailman/listinfo/mkiv
> 
> __________________________________________________
> Do You Yahoo!?
> Tired of spam?  Yahoo! Mail has the best spam
> protection around 
> http://mail.yahoo.com 
> _______________________________________________
> Mkiv mailing list
> Mkiv at mkiv.com
> http://www.mkiv.com/mailman/listinfo/mkiv
> 


Marlon
'84 Celica GT 5-spd
'94 Supra TT A340E


		
____________________________________________________
Start your day with Yahoo! - make it your home page 
http://www.yahoo.com/r/hs 
 
_______________________________________________
Mkiv mailing list
Mkiv at mkiv.com
http://www.mkiv.com/mailman/listinfo/mkiv